Email this article THE INFLUENCE OF PLASTIC DEFORMATION OF TiNi WIRE ON THE THERMOKINETIC EMF
- Authors: Rubanik Jr. V.V.1, Lesota A.V.1
-
Affiliations:
- Institute of Technical Acoustics of National Academy of Sciences of Belarus, Vitebsk
- Issue: No 3 (2017)
- Pages: 97-102
- Section: Technical Sciences
- URL: https://vektornaukitech.ru/jour/article/view/222
- DOI: https://doi.org/10.18323/2073-5073-2017-3-97-102
- ID: 222
Cite item
Full Text
Abstract
The initiation of thermokinetic EMF in titanium nickelide alloys is possible when shifting both the heating zone along the extended TiNi sample and the locally cooled zone. In this case, heating in the conductor local zone causes the reverse phase transformation (T≥As), and cooling causes the direct phase transformation (T≤Ms).
Previously, it was experimentally proved that the value of induced EMF increases when shifting the cooling zone through the locally deformed area, and the EMF increase depends on the deformation of TiNi sample. It should be noted that the physical nature of this phenomenon is not entirely investigated.
The paper suggests a physical model, according to which the thermokinetic EMF is initiated in the result of the difference of potentials in the areas with direct and reverse phase transformations occurring when shifting the cooling zones along TiNi alloy. When the cooling area passes the deformed zone, the EMF, caused both by the difference of thermo-EMF ratios of the deformed and non-deformed areas of TiNi sample and thermal effect, arises at the boundaries of deformation zones. Mathematical expressions allowing the calculation of thermokinetic EMF value change when passing a plastically deformed area were obtained. These expressions prove that thermokinetic EMF increases with the plastic deformation increase (the length of the deformed area is 6 cm).
The results of calculation of thermokinetic EMF change, when the cooling zone passes through the deformation zone in the TiNi alloys, fit the experimental data and can be used when developing methods of control of the extended TiNi products’ homogeneity.
About the authors
Vasiliy Vasilievich Rubanik Jr.
Institute of Technical Acoustics of National Academy of Sciences of Belarus, Vitebsk
Author for correspondence.
Email: ita@vitebsk.by
PhD (Physics and Mathematics), senior researcher
BelarusAnna Viktorovna Lesota
Institute of Technical Acoustics of National Academy of Sciences of Belarus, Vitebsk
Email: ita@vitebsk.by
junior researcher
BelarusReferences
- Furmakov E.F. Electric current induced by the motion of phase interface in a metal. Fundamentalnye problemy estestvoznaniya, 1999, no. 21, pp. 377–378.
- Furmakov E.F. Thermokinetic EMF sensor. Sbornik tezisov odinnadtsatoy Mezhdunar. konf. “Krym 2004”. Moscow, 2004, pp. 11–12.
- Rubanik V.V., Lesota A.V., Rubanik V.V. Jr. Calculation of the thermokinetic EMF during a reverse phase transformation in TiNi alloys. Letters on materials, 2017, vol. 7, no. 2, pp. 96–100.
- Rubanik V.V., Rubanik V.V. Jr., Lesota A.V. Thermoelectric phenomena during the direct phase transformation in a TiNi alloy. Materialy 8 mezhdunar. nauch.-tekhn. konf. “Priborostroenie-2015”. Minsk, 2015, vol. 1, pp. 24–26.
- Rubanik V.V., Rubanik V.V. Jr., Lesota A.V. Control of the state of strain of extended TiNi goods using the thermokinetic EMF. VII Mezhdunar. shkola s elementami nauchnoy shkoly dlya molodezhi “Fizicheskoe materialovedenie”. Togliatti, 2016, pp. 237–242.
- Kulkova S.E., Lalujsky D.V., Smolin I.Yu. Changes in the electronic structure upon the B2-B19’ martensitic transformation in titanium-nickel. Physics of the solid state, 2001, vol. 43, no. 4, pp. 737–745.
- Matsumoto H. Enhancement of a peak in electrical resistivity of NiTi alloy in early stage of transformation cycles. Journal of alloys and compounds, 2004, vol. 364, no. 1-2, pp. 132–136.
- Ramachandran B., Tang R.C., Chang P.C., Kuo Y.K., Chien C., Wu S.K. Cu-substitution effect on thermoelectric properties of the TiNi-based shape memory alloys. Journal of applied physics, 2013, vol. 113, no. 20, p. 203702.
- Anatychuk L.I., Bulat L.P. Thermoelectric phenomena under large temperature gradients. Thermoelectrics Handbook: macro to nano-structured materials. New York, CRC Press, 2005, pp. 3–11.
- Golestaneh A.A. Martensitic phase transformation in shape-memory alloys. International Conference on Martensitic Transformation. Cambridge, 1979, pp. 679–692.
- Benedicks С. Tetziger. Stand grundlegenden Keuntrisse der Thermoelektrizität. Erg. Exact. Naturwiss, 1929, bd. 8, pp. 26–67.
- Rubanik V.V., Rubanik V.V. Jr., Petrova-Burkina O.A. Thermoelastic phenomena manifestation in NiTi. Vliyanie elektromagnitnykh poley na plastichnost i prochnost materialov. Novokuznetsk, 2011, pp. 60–65.
- Gyunter V.E., Khodorenko V.N. Nikelid titana. Meditsinskiy material novogo pokoleniya [Nickel titanium. Medical material of the new generation]. Tomsk, MITs Publ., 2006. 286 p.
- Liang C., Rogers C.A. One-dimensional thermomechanical constitutive relations for shape memory materials. Journal of Intelligent Material Systems and Structures, 1990, vol. 1, no. 2, pp. 207–234.
- Shchennikov V.V., Ovsyannikov S.V., Vorontsov G.V. Investigations of multiphase states in vicinity of pressure-induced phase transitions. Physica Status Solidi (b), 2004, vol. 241, no. 14, pp. 3203–3209.
- Shchennikov V.V., Ovsyannikov S.V., Derevskov A.Y., Shchennikov V.V. Jr. Automated portable high-pressure setup for study of phase transitions in solids. Journal of Physics and Chemistry of Solids, 2006, vol. 67, no. 9-10, pp. 2203–2209.
- Ovsyannikov S.V., Shchennikov V.V., Komarovskii I.A., Vorontsov G.V., Korobeynikov I.V., Shchennikov V.V. Jr. Electrical and mechanical properties of multi-phase systems under external impacts. Proceedings of the SPIE, 2011, vol. 7978, id. 79781W.
- Lukhvich A.A. Vliyanie defektov na elektricheskie svoystva metallov [The influence of defects on the electric properties of metals]. Minsk, Nauka i tekhnika Publ., 1976. 99 p.
- Likhvich A.A., Karolik A.S., Sharando V.I. Strukturnaya zavisimost termoelektricheskikh svoystv i nerazrushayushchiy kontrol [Structure dependence of thermoelectric properties and nondestructive control]. Minsk, Nauka i tekhnika Publ., 1990. 192 p.
- Rubanik V.V., Rubanik V.V. Jr., Lesota A.V. Thermoelectric phenomena in deformed TiNi alloy. Materialy 8 Evraziyskoy nauch.-prakt. konf. “Prochnost neodnorodnykh struktur PROST-2016”. Moscow, 2016, pp. 59–61.
Supplementary files
